SECTION 1: MATERIAL SAFETY DATA SHEET
HITT MARKING DEVICES, INC.
3231 W. MACARTHUR BLLVD
SANTA ANA, CA 92704
EMERGENCY PHONE 714-979-1405
FAX NUMBER 714-979-140
WWW.HITTMARKING.COM INK NAME 42M INK DATE PREPARED 04/23/04
HEALTH: 1 CODE: 0=MINIMAL
FLAMMABILITY: 2 1=SLIGHT
REACTIVITY: 0 2=MODERATE
PERSONAL PROTECTION: B 3=SERIOUS
SECTION 2: HAZARDOUS INGREDIENTS
INGREDIENT PERCENT ACGIH-TLV OSHA – PEL GAS NO
CELLOSOLVE SOLVENT 25.00 5 PPM 200 PPPM 110-80-5
DIACETONE ALCOHOL 18.00 50 PPM 50 PPM 123-42-2
METHYL CARBITOL 18.00 NONE ESTAB NONE ESTAB 111-77-3
THIS CHEMICAL IS SUBJECT TO THE REPORTING REQUIREMENTS OF SARA TITLE III, SECTION 313 OF THE EMERGENCY
PLANNING AND COMMUNITY RIGHT TO KNOW ACT OF 1986 AND OF 40 CFR 372. THIS PRODUCT IS IN COMPLIANCE WITH
SECTION 3: PHYSICAL & CHEMICAL CHARACTERISTICS\
BOILING POINT: 336 F
MELTING POINT: -130 F
VAPOR DENSITY: 4.0
SPECIFIC GRAVITIY: .9406
REACTIVITY IN WATER: NONE
SOLUBILITY IN WATER: SLIGHT
AUTO IGNITION: 750 F
VAPOR PRESSURE: <1 MM HG
APPEARANCE & ODOR: MOBILE LIQUID, MILD ODOR
APPEARANCE & ODOR: VOC: 28.59 GMS/L
LEL/UEL %: 1.5 14.0
FLASH POINT: 120 F
SECTION 4: FIRE & EXPLOSION DATA
EXTINGUISHING MEDIA: CARBON DIOXIDE
EXTINGUISHING MEDIA: DRY CHEMICAL
EXTINGUISHING MEDIA: ALCOHOL RESISTANT FOAM
EXTINGUISHING MEDIA: UNIVERSAL FOAM
EXTINGUISHING MEDIA: WATERSPRAY
SPECIAL FIRE PROCEDURES: WEAR SELF-CONTAINED BREATHING APPARATUS
SPECIAL FIRE PROCEDURES: WEAR PROTECTIVE CLOTHING AND EQUIPMENT
SPECIAL FIRE PROCEDURES:USE WATERSPRAY TO COOL FIRE-EXPOSED AREA
SPECIAL FIRE PROCEDURES: USE WATERSPRAY TO PROTECT PERSONNEL
UNUSUAL HAZARDS: WEAR FACE SHIELD TO PROTECT FACE
UNUSUAL HAZARDS: EYES FROM CONTACT WITH LIQUID OR VAPOR.
SECTION 5: REACTIVITY DATA
STABLE, Y=YES, N=NO : Y
CONDITIONS TO AVOID: HEAT, SPARKS AND OPEN FLAME
INCOMPATABILITY: STRONG OXIDIZING MATERIAL
HAZARDOUS DECOMPOSITION: BURNING WILL PRODUCE CO2 AND PROBALY CO
HAZARDOUS POLYMERIZATION WILL NOT OCCUR
CONDITIONS TO AVOID: NONE
SECTION 6: HEALTH HAZARDS
ACUTE: HEADACHE, NAUSEA, VOMITING
CHRONIC: SKIN AND EYE IRRITANT
CHRONIC: INJURY TO BLOOD CELLS, LIVER & KIDNEYS
SIGNS & SYMPTOMS OF EXPOSURE: DIZZINESS, DROWSINESS, FATIGUE
SIGNS & SYMPTOMS OF EXPOSURE: LOSS OF COORDINATION
SIGNS & SYMPTOMS OF EXPOSURE: LOSS OF APPETITE
MEDICAL CONDITIONS AGGRAVATED: IN LAB INHALATION TESTS STUDIES WITH ANIMALS, CELLOSOLVE SOLVENT HAS CAUSED BIRTH DEFECTS IN FEMALES & REPRODUCTIVE PROBLEMS IN MALES; NO HUMAN RESULTS CITED IS
MEDICAL CONDITIONS AGGRAVATED: PROBLEMS IN MALES: NO HUMAN RESULTS CITED IS CHEMICAL LISTED AS CARCINOGEN OR POTENTIAL CARCINOGEN?
NATIONAL TOXICOLOGY PROGRAM, Y=YES, N=NO: N
IARC MONGRAPHICS, Y=YES, N=NO: N
OSHA, Y=YES, N=NO: N
FIRST AID FOR INHALATION: REMOVE TO FRESH AIR IF OVERCOME BY VAPOR
FIRST AID FOR EYES: IRRIGATE WITH CLEAN WATER FOR 15 MINUTES
FIRST AID FOR SKIN: WASH WITH SOAP & WATER; CHANGE CLOTHING
FIRST AID FOR INGESTION: GIVE TWO GLASSES OF LUKEWARM WATER, INDUCE VOMITINIG: CALL DOCTOR
ROUTES OF ENTRY FOR INHALATION: AVOID PROLONGED BREATHING OF VAPORS
ROUTES OF ENTRY FOR EYES: AVOID ALL CONTACT WITH THE EYES
ROUTES OF ENTRYFOR SKIN: AVOID REPEATED OR PROLONGED SKIN CONTACT
ROUTES OF ENTRY FOR INGESTION: DO NOT TAKE INTERNALLY
SECTION 7: SPECIAL PRECAUTIONS & SPILL/LEAK PROCEDURES
HANDLING & STORAGE: KEEP CONTAINER CLOSED WHEN NOT IN USE
HANDLING & STORAGE: USE ONLY WITH PROPER VENTILATION
HANDLING & STORAGE: AVOID PROLONGED BREATHING OF VAPORS
HANDLING & STORAGE: KEEP AWAY FROM HEAT AND FLAME
STEPS IF SPILLED: REMOVE IGNITION SOURCES; VENTILATE
STEPS IF SPILLED: SWEEP UP AND PUT IN CHEMICAL WASTE DRUM
STEPS IF SPILLED: DO NOT ALLOW SPILL TO ENTER WATERWAYS
WASTE DISPOSAL: INCINERATE IN CHEMICAL FURNACE
WASTE DISPOSAL: MUST CONFORM TO LOCAL, STATE & FEDERAL REGULATIONS
SECTION 8: SPECIAL PROTECTION INFORMATION
RESPIRATORY PROTECTION: GENERAL ROOM VENTILATION IS SATISFACTORY
VENTILATION: PROVIDE ADEQUATE CROSS AIR CIRCULATION
LOCAL EXHAUST: PREFERABLE
SECTION 8: SPECIAL PROTECTION INFORMATION
REPIRATORY PROTECTION: GENERAL ROOM VENTILATION IS ADEQUATE
VENTILATION: PROVIDE ADEQUATE CROSS AIR CIRCULATION
LOCAL EXHAUST: PREFERABLE
MECHANICAL: ACCEPTABLE
SPECIAL: NIOSH APPROVED RESPIRATOR FOR HIGH VAPOR
PROTECTIVE GLOVES: CHEMICAL INPERVIOUS
EYE PROTECTION: SPLASH GLASSES
OTHER PROTECTION: EYEWASH STATION
WORK/HYGENIC PRACTICES: THIS PRODUCT SHOULD NOT BE USED BY PREGANANT WOMEN.
SPECIAL MESSAGE SECTION
THE HAZARDS LISTED ON THIS MSDS ARE TAKEN FROM THE MSDS FOR EACH OF THE INGREDIENTS IN THIS MIXTURE.
IN MOST CASES, THE MAXIUM FORM OF HAZARD IS REPRESENTED HERE. THE TLV’S REPRESENTTHE CONDITIONS UNDER WHICH IT IS BELIEVED THAT NEARLY ALL WORKERS MAY BE REPEATEDLY EXPOSED DAY AFTER DAY WITHOUT ADVERSE EFFECT. IT MUST BE REMEMBERED THAT EACH INDIVIDUAL REACTS DIFFERENTLY AND SOME MAY EXPERIENCE DISCOMFORT WHILE OTHERS DO NOT. THIS MSDS IS PRESENTED SO THAT EACH INDIVIDUAL WILL HAVE THE INFORMATION TO DEAL SAFETY WITH THE USE OF THIS PRODUCT. ALL MATERIALS TSCA LISTED.
DISCLAIMER SECTION
DISCLAIMER OF LIABILITY:
AS THE CONDITIONS OR METHODS OF USE ARE BEYOND OUR CONTROL, WE DO NOT ASSUME ANY RESPONSIBILITY AND EXPRESSLY DISCLAIM ALL LIABILITY FOR ANY USE OF THIS MATERIAL. INFORMATION CONTAINED HEREIN IS GIVEN IN GOOD FAITH AND BELIEVED TO BE TRUE AND ACCURATE. BUT ALL STATEMENTS OR SUGGESTIONS ARE MADE WITHOUT ANY WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OF THE INFORMATION, THE HAZARDS CONNECTED WITH THE USE OF THE MATERIAL OR RESULTS OT BE OBTAINED FROM THE USE THEREOF.
INFORMATION ON MSDS SUPPLIED BY INK MFG.
PREPARED BY: ALLEN WERWA, SAFETY DIRECTOR 04/23/04